floatation of copper ore

Copper Flotation - Mineral Processing & Metallurgy

May 16, 2016 · A Copper Flotation Flowsheet. Because the copper in this type of ore usually assays only plus or minus 1% copper, the porphyry copper operations must be relatively large in order to be commercial. The flowsheet in this study illustrates a typical 3,000 ton per day operation. In general most operations of this type have two or more parallel ...

Copper Flotation - Elmhurst University

Ore Concentration by Froth Flotation. Remember that only 0.67% of the ore is copper. The copper minerals and waste rock are separated at the mill using froth flotation. The copper ore slurry from the grinding mills is mixed with milk of lime (simply water and ground-up limestone) to give a basic pH, pine oil (yes, it comes from trees -- a by ...

Copper Sulfide Flotation - Mineral Processing & Metallurgy

Apr 13, 2016 · Flowsheet for treatment of Copper Sulfide ores rich inminerals such as chalcopyrite with gold and silver as well as arsenopyrite. The above flowsheet is designed for the treatment by flotation of copper as chalcopyrite with gold and silver values. The ore, ranging from 60-65% silica, with pyrite, arsenopyrite, and calcite with 3 to 4% copper.

(PDF) A Review of the Flotation of Copper Minerals

Sulphide ores are the major sources of base metals like Copper, Lead, Zinc, Nickel and Cobalt. Beneficiation of. these base metal sulphide minerals is predominantl y through the froth flotation ...

(PDF) BULK FLOTATION OF COMPLEX COPPER ORE | Khmer Lee ...

One kilogram of ore, at -200 mesh was used as feed to the bulk flotation that was conducted for 8 minutes. Two collectors, independently added, were used at 3 different dosages: 20, 30, and 40 g/ton. The copper and zinc contents were determined as well

1 Froth Flotation – Fundamental Principles

Problem: A copper ore initially contains 2.09% Cu. After carrying out a froth flotation separation, the products are as shown in Table 1. Using this data, calculate: (a) Ratio of concentration (b) % Metal Recovery (c) % Metal Loss (d) % Weight Recovery, or % Yield (e) Enrichment Ratio

Flotation of mixed copper oxide and sulphide minerals with ...

Mar 01, 2009 · Traditional sulphidisation flotation techniques, which are widely used on copper oxide ore, can not be used in sulphide/oxide blends for simultaneous sulphide and oxide copper flotation as the sulphidising reagent will suppress the flotation of sulphide minerals as shown within this case study.

Estimated Water Requirements for the Conventional ...

Figure 1 is a generalized diagram of a conventional copper flotation plant from the point where ore first enters the circuit to the production of concentrate and tailings. To prepare ore for the flotation process, run-of-mine ore, which may contain from about 2 to 5 percent water, by weight, when mined, is

Mechanism and application on sulphidizing flotation of ...

Jan 01, 2019 · The actual ores flotation shows that when the dosage of NaBX+DDA is (100+54) g/t, the copper concentrate grade and recovery are 15.93% and 76.73%, respectively. The fluorescent pyrene probe test demonstrates that the NaBX+DDA can reduce the micelle concentration in the pulp.

Froth flotation - Wikipedia

Froth flotation is a process for selectively separating hydrophobic materials from hydrophilic. This is used in mineral processing, paper recycling and waste-water treatment industries. Historically this was first used in the mining industry, where it was one of the great enabling technologies of the 20th century. It has been described as "the single most important operation used for the recovery and upgrading of sulfide o

Copper ore flotation process - YouTube

Jun 16, 2014 · The flotation machine is used for the separation of the nonferrous black metal as well as the separation of the non-metallic materials such as the coal fluor...

FLOTATION OF COPPER ORES - WESTON D,CA

A process for the flotation recovery of copper values from ores containing copper values in the form of at least one sulphide copper mineral and at least one sulphuric acid soluble copper mineral using a sulfhydryl anionic collector comprising: preparing a pulp of the ore by grinding the ore to flotation feed size in a wet grinding circuit ...

Flotation of mixed copper oxide and sulphide minerals with ...

Mar 01, 2009 · Traditional sulphidisation flotation techniques, which are widely used on copper oxide ore, can not be used in sulphide/oxide blends for simultaneous sulphide and oxide copper flotation as the sulphidising reagent will suppress the flotation of sulphide minerals as shown within this case study.

(PDF) Flotation of an Oxidized Copper Sulfide Ore

Dec 30, 2017 · The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H2SO4) leaching. The ore with 4.21% copper grade used in

Copper Ore - an overview | ScienceDirect Topics

17.7 Flotation of Gold-Containing Copper Ores. The floatability of gold from gold-containing copper gold ores depends on the nature and occurrence of gold in these ores, and its association with iron sulphides. Gold in the porphyry copper ore may appear as native gold, electrum, cuproaurid and sulphosalts associated with silver. During the ...

FLOTATION OF COPPER SULFIDE ORES - STEPHAN CHEM CO,US

The ore is a sulfide copper ore containing heads of approximately: copper 0.45, iron 3.5, molybdenum 0.006, and zinc 0.06 per ore sample. Prior flotation of this ore has employed, in the flotation cell, the addition of pine oil as required to optimize froth, ordinarily resulting in a total pine oil concentration of about 0.24 lb./ton.

Flotation of oxide copper ore with sodium oleate from the ...

The flotation of oxide copper ore with sodium oleate was investigated to determine the optimum pH and dosages of chemical reagents. From the mineralogical analysis using X-ray diffraction, malachite was the major mineral and the gangue minerals were mostly silicates such as quartz and kaolinite. As a result this ore was characterized as oxide ...

RECOVERY OF COPPER FROM OXIDE COPPER ORE BY

The aim of this study was the recovery of copper from the oxide copper ore by froth flotation and agitating sulphuric acid (H 2 SO 4) leaching. The ore with 4.21% copper grade used in this study was obtained from Çorum-Dangaz region of Turkey. Native copper, cuprite (Cu 2 O), tenorite (CuO), and malachite (Cu 2 (OH) 2 /CO 3) were the

Effect of bacterial conditioning and the flotation of ...

copper grade increase of about 22% in flotation copper ore through bacterial conditioning of pyrite surfaces resulting in pyrite depression. Key words: Chalcopyrite, bio-oxidation, bacteria, mineral surface, froth flotation. INTRODUCTION Acidothiobacillus ferrooxidans is an aerobic, acidophilic, rod-shaped, autotrophic, gram-negative bacterium.

LABORATORY CONCENTRATION OF VARIOUS ALASKA

A series of flotation tests was run to determine the best grind and reagent combination for treatment of the ore. Although good recoveries of copper were ob-tained by rougher flotation of ore ground to minus-48- or 65-mesh, difficulty was experienced in cleaning the rougher concentrate. Partial oxidation of the ore

floatation of copper sulphide ore

Flotation of Nickel-Copper Sulphide Ore: the flotation recovery of Ni, Cu and Co from a nickel-copper sulphide ore. The effect on flotation performance of various parameters such as pH, collector dosage, % solids and depressant dosage at different levels was investigated. Therefore, the main objective of the study was to optimize the process ...

Copper extraction - Wikipedia

Copper extraction refers to the methods used to obtain copper from its ores.The conversion of copper consists of a series of physical and electrochemical processes. Methods have evolved and vary with country depending on the ore source, local environmental regulations, and other factors.. As in all mining operations, the ore must usually be beneficiated (concentrated).

Effect of Desliming on Flotation Response of Kansanshi ...

The Kansanshi mixed copper sulfide-oxide ore contains significant proportions of fine material manifesting in a variety of processing challenges. This paper presents the work which was carried out to evaluate the efficacy of desliming in improving the flotation response of the ore. Two modes of desliming were investigated, namely; sieving and elutriation after which the deslimed material was ...

Mineralogical Prediction on the Flotation Behavior of ...

The flotation parameter and the blending ratio of copper-molybdenum ore were dictated by the condition of the real flotation plant, thus, the only variable to be investigated is the effect of mineral composition of each copper-molybdenum ores.

Chapter 12: Flotation of Copper Sulfide Ores | Engineering360

The most important economic copper minerals are chalcopy-rite, chalcocite, bornite and covellite. Table 12.1 lists the copper minerals of economic value. Copper sulfide ores, where the pyrite content can vary from 10% to 90%. The predominant sulfide mineral in this ore is

Flotation of low grade copper ore from Kallur, Raichur ...

Flotation Chalcopyrite from the ore ground to —150 mesh is best concentrated by the flotation pro-cess, by depressing gangue minerals like quartz, feldspar, calcite and pyrite and floating the copper mineral using a xanthate as collector. 500 gms of the ground ore obtained by coning and quartering was subjected to froth flotation

FLOTATION OF COPPER SULFIDE ORES - STEPHAN CHEM CO,US

The ore is a sulfide copper ore containing heads of approximately: copper 0.45, iron 3.5, molybdenum 0.006, and zinc 0.06 per ore sample. Prior flotation of this ore has employed, in the flotation cell, the addition of pine oil as required to optimize froth, ordinarily resulting in a total pine oil concentration of about 0.24 lb./ton.

A New Application For Flotation Of Oxidized Copper Ore

In this study, the flotation of oxidized copper ore obtained from Ergani Copper Mining Company in Turkey was performed. This ore contains 2.03% copper, 0.15% cobalt and 3.73% sulfur. An effective processing method has not been found to recover copper and cobalt from this ore, which has been stockpiled for 40-45 years in the idled plant.

floatation of copper sulphide ore

Flotation of Nickel-Copper Sulphide Ore: the flotation recovery of Ni, Cu and Co from a nickel-copper sulphide ore. The effect on flotation performance of various parameters such as pH, collector dosage, % solids and depressant dosage at different levels was investigated. Therefore, the main objective of the study was to optimize the process ...

12.3 Primary Copper Smelting

Mining produces ores with less than 1 percent copper. Concentration is accomplished at the mine sites by crushing, grinding, and flotation purification, resulting in ore with 15 to 35 percent copper. A continuous process called floatation, which uses water, various flotation chemicals, and compressed air, separates the ore into fractions.

Selectivity and power of frothers in copper ore flotation

Selectivity and power of frothers in copper ore flotation 517 The ore was crushed in a jaw crusher to obtain particles smaller than 1 mm in size. Prior to each flotation experiment, the crushed material was wet ground in a steel ball mill. The size distribution of the ore, used as the flotation feed, is presented in Table 1. Table 1.

Review, Evolution and Optimization of the Kansanshi Mixed ...

The traditional method applied for the flotation of copper oxide or mixed ores is sulphidisation, which was first developed with industrial success on Pb–Zn oxide ores in Australia (Crozier, 1991). The method involves multistage addition of sodium sulphide (Na 2

Acid leaching of oxide–sulfide copper ore prior the ...

453 Acid leaching of oxide–sulfide copper ore prior the flotation – A way for an increased metal recovery Miroslav D. Sokić1, Vladan D. Milošević1, Velizar D. Stanković2, Vladislav Lj.Matković1, Branislav R. Marković1 1Institute for Technology of Nuclear and Other Mineral Raw Materials, Belgrade, Serbia 2University of Belgrade, Technical Faculty, Bor, Serbia

Effect of Desliming on Flotation Response of Kansanshi ...

The Kansanshi mixed copper sulfide-oxide ore contains significant proportions of fine material manifesting in a variety of processing challenges. This paper presents the work which was carried out to evaluate the efficacy of desliming in improving the flotation response of the ore. Two modes of desliming were investigated, namely; sieving and elutriation after which the deslimed material was ...

Chemical and Mineral Analysis of Flotation Tailings from ...

Sep 27, 2019 · From the beginning of copper ore mining, the problem of utilization and managing the deposited tailings has been discussed. Annually, all three concentrators produce above 30 million tons of flotation tailings. Lubin Concentrator Plant processes the most complex in upgradeability ore from the other two concentrators.

Flotation collectors | Solvay

Flotation collectors. Designed to operate across a broad range of alkalinity levels and provide faster flotation kinetics, our flotation collectors have become the industry standard in the recovery of copper, gold, molybdenum, lithium and other metals. AEROPHINE®, AERO® and AEROFLOAT® collectors (promoters) are used extensively for the ...

Flotation flowsheet of copper, lead, zinc and other ...

Flotation flowsheet of copper, lead, zinc and other Polymetallic Sulphide Ores. Direct preferential flotation process. Flotation processes of various useful minerals are sequentially floatation, which is called preferential flotation process. The characteristics of the process can be adapted to the change of ore grade and has higher flexibility.

Flotation of Fully Liberated Low Grade Copper-Nickel Ore

Mar 21, 2021 · water. Flotation was started by opening the air valve, and the air flow was adjusted to 4 L/min, while the copper concentrate was collected for five minutes followed by the nickel concentrate. The concentrates were weighed and dried in an oven overnight. Small samples of copper and nickel concentrates along with feed sample were cast into ...

Copyright © 2020.Company name All rights reserved.SiteMap